Product ID:SEA GULL GRAY SG AD EN
MSDS Date:05/14/1987
FSC:8010
NIIN:00-855-0439
MSDS Number: BKSTG

STERLING LACQUER MFG CO INC

3150 BRANNON AVE
ST LOUIS, MO 63139
US

Emergency Phone: 314-776-4450

Info Phone: 314-776-4450

Preparer: P. D. MOORE

Cage: 60003

STERLING LACQUER MFG CO

ST. LOUIS, MO 63139-1422 US

Telephone: 314-776-4450

Cage: 60003

15.0 MM HG 100F)

CAS: 8030-30-6

RTECS: DE3030000

Fraction By Weight: 30%

OSHA PEL 500 PPM

ACGIH TLV: 300 PPM

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: < 5%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LEAD (SARA III)

CAS: 7439-92-1

RTECS: OF7525000

Fraction By Weight: 0.10%

OSHA PEL 0.05 MG/M3;1910.1025

ACGIH TLV: 0.15 MG/M3;DUST 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: < 5.0%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

3.7 LB/GL (447 GR/LT)

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALE: IRRITATION TO THE RESPIRATORY
TRACT (NOSE, THROAT, LUNGS). SKIN/EYE: IRRITATING. MAY INJURE EYE
TISSUE IF NOT PROPERLY REMOVED. SKIN ABSORB: SLIGHT IRRITATION DUE
TO SOLVENTS. INGEST: INGESTIO N CAN RESULT IN LEAD POISONING.
MODERATELY TOXIC. MAY CAUSE NAUSEA, VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS CAN BE
INCREASED BY INHALATION OF VAPORS.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED AREA
WITH SOAP AND WATER. INHALE: MOVE TO FRESH AIR. OBTAIN MEDICAL
ATTENTION IF NEEDED. INGEST: DO NOT INDUCE VOMITING GET IMMEDIATE
MEDICAL AID. CONTAINS LEAD.

Flash Point Method:TCC
Flash Point:45.0F,7.2C
Lower Limits:0.9
Upper Limits:10.7
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACE PIECE OPERATED IN PRESSURE-DEMAND WHEN FIGHTING FIRES.
USE WATER FOG NOZZLES TO COOL CLOSED CONTAINER.
Unusual Fire/Explosion Hazard:DO NOT USE WATER. FLAMMABLE LIQUID, CAN
RELEASE VAPORS THAT FORM FLAMMABLE MIXTURE AT TEMP AT OR GREATER
THAN FLASHPOINT. ELIM & ISOLATE FROM IGNITE SOURCES.

Spill Release Procedures:WEAR RESPIRATOR, ABSORB WITH VERMICULITE OR
OTHER ABSORBENT MATERIAL. ELIMINATE ALL IGNITION SOURCES. STOP
SPILL AT SOURCE AND PREVENT SPREADING.

Handling and Storage Precautions:STORE IN DRY AREA. KEEP TIGHTLY
CLOSED. PROTECT FROM PHYSICAL DAMAGE. EMPTIED CONTAINERS RETAIN
PRODUCT RESIDUES. OBSERVE PRECAUTIONS STORE BELOW 20F.
Other Precautions:STORE LARGE QUANTITIES ACCORDING TO OSHA 1910.106.
KEEP CLOSURE TIGHT & CONTAINER UPRIGHT TO PREVENT LEAKAGE. DO NOT
STORE NEAR HEAT, SPARKS OR FLAME. DO NOT GET IN EYES. KEEP AWAY
FROM CHILDREN. AVOI D SKIN CONTACT. DO NOT TAKE INTERNALLY.

Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED, A NIOSH/MSHA APPROVED AIR SUPPLY RESPIRATOR IS ADVISED IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO
PERMIT OTHER NIOSH/MSHA RES PIRATORS UNDER SPECIFIED CONDITIONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLVS.
Protective Gloves:SOLVENT RESISTANT GLOVES.
Eye Protection:PREFER SPLASH GOGGLES; SAFETY GLASSES
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR SOLVENT IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER USE, BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
FOR INDUSTRIAL USE. PRODUCT CONTAINS LEAD. ENGINEERING OR
ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED FOR SAFETY.

Boiling Pt:B.P. Text:230 TO 243F
Vapor Density:> AIR
Spec Gravity:1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY LIQUID, SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT.
Hazardous Decomposition Products:BURNING CAN PRODUCE CARBON DIOXIDE
AND/OR CARBON MONOXIDE.

Waste Disposal Methods:DESTROY BY LIQUID INCINERATION. CONTAMINATED
ABSORBENT MAY BE DEPOSITED IN A LANDFILL IN ACCORDANCE WITH
FEDERAL, STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.